Deformation of Plates with Pre-formed Holes under Internal Blast Loading in Cabin Model

ZHAO Pengduo; WANG Qing; ZHANG Lei; ZHANG Peng; HUANG Song; XU Yuxin

doi:10.11858/gywlxb.20180531

Volume 32 Issue 6

Dec 2018

Turn off MathJax

Article Contents

Chinese Journal of High Pressure Physics > 2018 > 32(6): 065110.

ZHAO Pengduo, WANG Qing, ZHANG Lei, ZHANG Peng, HUANG Song, XU Yuxin. Deformation of Plates with Pre-formed Holes under Internal Blast Loading in Cabin Model[J]. Chinese Journal of High Pressure Physics, 2018, 32(6): 065110. doi: 10.11858/gywlxb.20180531

Citation:

ZHAO Pengduo, WANG Qing, ZHANG Lei, ZHANG Peng, HUANG Song, XU Yuxin. Deformation of Plates with Pre-formed Holes under Internal Blast Loading in Cabin Model[J]. Chinese Journal of High Pressure Physics, 2018, 32(6): 065110. doi: 10.11858/gywlxb.20180531

Citation:

PDF( 4172 KB)

Deformation of Plates with Pre-formed Holes under Internal Blast Loading in Cabin Model

doi: 10.11858/gywlxb.20180531

ZHAO Pengduo^1
,,
WANG Qing^{1, 2},
ZHANG Lei¹,
ZHANG Peng^{1, 2},
HUANG Song^{1, 2},
XU Yuxin³

1.
Naval Research Academy, Beijing 100161, China
2.
College of Mechatronic Engineering, North University of China, Taiyuan 030051, China
3.
State Key Laboratory of Explosion Science and Technology, Beijing Institute of Technology, Beijing 100081, China

Received Date: 28 Mar 2018
Rev Recd Date: 10 Apr 2018

Abstract

Abstract

In order to investigate the dynamic response of plates with preformed holes under internal blast load in the cabin model, the deformations of the plates with offset preformed holes and the plates with uniform preformed holes in the cabin model were experimentally investigated.The results are also compared with that of the plates with non-preformed holes.The numerical calculation of the internal blast load was carried out by using established simulation model of cabin.The distribution of internal blast shock waves at typical gauge points was analyzed and the deformation rules of plates with preformed holes were studied as well.The research results indicate that the effect of gain of deflection deformation obtained from decreasing local strength due to the preformed holes is greater than that of the blast venting.The shock wave exhibits the reflection and convergence phenomena inside the cabin model and a quasi-static feature during the late stage of milliseconds.The simulation results are consistent with the experimental ones.At the same time, there are differences between the thinning rates in different areas of the plates with preformed holes.The current research can provide reference for the analysis of the mechanism of coupling damage between shock wave and fragments in the cabin.
- cabin model,
- plates with pre-formed holes,
- internal blast shock waves,
- gain of deflection,
- thinning rate

FullText(HTML)

References(13)

References

[1]	RUSHTON N, SCHLEYER G K, CLAYTON A M, et al.Internal explosive loading of steel pipes[J].Thin-Walled Structuers, 2008, 46(7/8/9):870-877. http://www.sciencedirect.com/science/article/pii/S0263823108000359
[2]	柏小娜, 李向东, 杨亚东.封闭空间内爆炸冲击波超压计算模型及分布特性研究[J].爆破器材, 2015, 44(3):22-26. doi: 10.3969/j.issn.1001-8352.2015.03.005 BAI X N, LI X D, YANG Y D.Calculation model and the distribution of wave pressure under internal explosion in closed space[J].Explosive Materials, 2015, 44(3):22-26. doi: 10.3969/j.issn.1001-8352.2015.03.005
[3]	FELDGUN V R, KOCHETKOV A V, KARINSKI Y S, et al.Internal blast loading in a buried lined tunnel[J].International Journal of Impact Engineering, 2007, 35(3):172-183. http://www.sciencedirect.com/science/article/pii/S0734743X07000073
[4]	侯海量, 朱锡, 李伟, 等.舱内爆炸冲击载荷特性实验研究[J].船舶力学, 2010, 14(8):901-907. doi: 10.3969/j.issn.1007-7294.2010.08.011 HOU H L, ZHU X, LI W, et al.Experimental studies on characteristics of blast loading when exploded inside ship cabin[J].Journal of Ship Mechanics, 2010, 14(8):901-907. doi: 10.3969/j.issn.1007-7294.2010.08.011
[5]	孔祥韶.爆炸载荷及复合多层防护结构响应特性研究.武汉:武汉理工大学, 2013:52-56. http://d.old.wanfangdata.com.cn/Thesis/Y2364126 KONG X S.Research on the blast loadings and the response of multi-laver protective structure.Wuhan:Wuhan University of Technology, 2013:52-56. http://d.old.wanfangdata.com.cn/Thesis/Y2364126
[6]	AUNE V, VALSAMOS G, CASADEI F, et al.On the dynamic response of blast-loaded steel plates with and without pre-formed holes[J].International Journal of Impact Engineering, 2017, 108(4):27-46. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=d18ff3d323b85b0a702c9928f709a9ba
[7]	RAKVÅG K G, UNDERWOOD N J, SCHLEYER G K, et al.Transient pressure loading of clamped metallic plates with pre-formed holes[J].International Journal of Impact Engineering, 2013, 53(3):44-55. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=a07446669f032aa99fcdc47aaec69b56
[8]	蒋建伟, 侯俊亮, 门建兵, 等.爆炸冲击波作用下预制孔靶板塑性变形规律的研究[J].高压物理学报, 2014, 28(6):723-728. http://www.gywlxb.cn/CN/abstract/abstract1768.shtml JIANG J W, HOU J L, MEN J B, et al.Study on deformation of perforated plates under blast loading[J].Chinese Journal of High Pressure Physics, 2014, 28(6):723-728. http://www.gywlxb.cn/CN/abstract/abstract1768.shtml
[9]	黄寅生.炸药理论[M].北京:北京理工大学出版社, 2016. HUANG Y S.Explosive theory[M].Beijing:Beijing Institute of Technology Press, 2016.
[10]	侯海量, 朱锡, 梅志远.舱内爆炸载荷及舱室板架结构的失效模式分析[J].爆炸与冲击, 2007, 27(2):151-158. doi: 10.3321/j.issn:1001-1455.2007.02.010 HOU H L, ZHU X, MEI Z Y.Study on the blast load and failure mode of ship structure subject to internal explosion[J].Explosion and Shock Waves, 2007, 27(2):151-158. doi: 10.3321/j.issn:1001-1455.2007.02.010
[11]	刘土光, 胡要武, 郑际嘉.固支加筋方板在爆炸载荷作用下的刚塑性动力响应分析[J].爆炸与冲击, 1994, 14(1):55-65. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=QK199400166734 LIU T G, HU Y W, ZHENG J J.Dynamic reeponse analysis of rigid perfectly plastic calmped square plates with stiffener subjected to blast loading[J].Explosion and Shock Waves, 1994, 14(1):55-65. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=QK199400166734
[12]	汪维, 张舵, 卢芳云, 等.大当量TNT装药爆轰的远场数值模拟及超压预测[J].弹箭与制导学报, 2010, 30(1):127-130. doi: 10.3969/j.issn.1673-9728.2010.01.039 WANG W, ZHANG D, LU F Y, et al.Simulation of thousands kilograms of TNT explosion shock wave in air at distance far away and forecast of the peak overpressure[J].Journal of Projectiles, Rockets, Missiles and Guidance, 2010, 30(1):127-130. doi: 10.3969/j.issn.1673-9728.2010.01.039
[13]	周杰, 陶钢, 潘宝清, 等.AUTO-DYN模拟炸药爆炸问题的分析[J].火炸药学报, 2012, 35(5):33-37. doi: 10.3969/j.issn.1007-7812.2012.05.008 ZHOU J, TAO G, PAN B Q, et al.Analysis of the problems of simulating the explosive blast by AUTO-DYN[J].Chinese Journal of Explosives & Propellants, 2012, 35(5):33-37. doi: 10.3969/j.issn.1007-7812.2012.05.008

Relative Articles

Supplements(0)

Cited By

Proportional views

Proportional views

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Figures(12) / Tables(6)

Get Citation

PDF

XML

Article Metrics

Article views(8108) PDF downloads(21)

Deformation of Plates with Pre-formed Holes under Internal Blast Loading in Cabin Model

doi: 10.11858/gywlxb.20180531

Abstract

References

Proportional views

Catalog

通讯作者: 陈斌, bchen63@163.com

Article Metrics

Proportional views

Related

Deformation of Plates with Pre-formed Holes under Internal Blast Loading in Cabin Model

doi: 10.11858/gywlxb.20180531

Abstract

References

Proportional views

Catalog

通讯作者: 陈斌, bchen63@163.com

Article Metrics

Proportional views

Related

Export File

Citation

Format

Content