强点火条件下RP-3航空煤油燃爆特性实验研究

毛浩清; 黄炜超; 李斌; 解立峰

doi:10.11858/gywlxb.20170583

强点火条件下RP-3航空煤油燃爆特性实验研究

doi: 10.11858/gywlxb.20170583

南京理工大学化工学院，江苏南京 210094

基金项目:

科技部国际科技合作重大专项 2013DFR60080

详细信息

作者简介:
毛浩清(1990—), 男，硕士研究生，主要从事燃烧、爆炸、爆轰及其作用机理研究.E-mail:Mao_haoqing@163.com

通讯作者:
解立峰(1965—), 男，博士，教授，博士生导师，主要从事多相爆轰理论与防火防爆技术研究.E-mail:xielifeng319@sina.com

中图分类号: O389; TE626
计量
- 文章访问数: 7230
- HTML全文浏览量: 3413
- PDF下载量: 288
出版历程
- 收稿日期: 2017-05-20
- 修回日期: 2017-06-05

Explosion Characteristics of RP-3 Aviation Kerosene Ignited by a High Explosive

School of Chemical Engineering, Nanjing University of Science and Technology, Nanjing 210094, China

摘要

摘要: 为进一步探究影响RP-3航空煤油燃爆特性参数的因素，在内径为200 mm、高度为5 400 mm的立式激波管中，采用强点火方式，测定了其在不同浓度下的临界起爆能以及不同起爆能量、浓度当量比、喷雾压力下RP-3航空煤油的爆速和爆压。实验结果表明：航空煤油的临界起爆能随浓度当量比的增加先急剧降低，达到最小值后又缓慢上升，基本呈“L”形变化；在喷雾压力为0.20~0.60 MPa、同一浓度条件下，RP-3航空煤油的爆速、爆压随喷雾压力的变化曲线呈倒“U”形；随着起爆能量升高，爆速、爆压均呈直线上升趋势，并且当起爆能量小于1.68 MJ/m²时，煤油未达到直接爆轰状态；燃料的爆速、爆压随浓度当量比的增加先上升后下降，其变化趋势也基本呈倒“U”形。
- RP-3航空煤油 /
- 立式激波管 /
- 强点火 /
- 临界起爆能 /
- 爆速 /
- 爆压
Abstract: In this study, the deflagration and detonation parameters of RP-3 aviation kerosene in a vertical shock tube, 200 mm in inner diameter and 5 400 mm in height, was measured at different initiation energies, spray pressures and equivalence ratios in direct ignition by a high explosive to further explore the influencing factors of the combustion characteristics of the RP-3 aviation kerosene.The results show that the critical initiation energy of the aviation kerosene decreases sharply at first and then rises slowly with the increase of the equivalence ratio, and its changing trends are basically in an "L" shape.When the spray pressure varies from 0.20 MPa to 0.60 MPa, the detonation velocity and the explosion pressure are both in the shape of an inverted "U" along with the changing of the spray pressure at the same fuel concentration.The detonation velocity and the explosion pressure curves have a linear ascending tendency with the increase of the initiation energy.Moreover, when the initiation energy ranges from 0.37 MJ/m² to 1.68 MJ/m², the aviation kerosene cannot reach the state of detonation.The detonation velocity and the explosion pressure of the fuel at first increase and then decrease along with the rising of the equivalence ratio, also in an inverted "U" shape.
- RP-3 aviation kerosene /
- vertical shock tube /
- direct ignition /
- critical initiation energy /
- detonation velocity /
- explosion pressure

HTML全文

图 1 立式激波管示意图

Figure 1. Structure of the vertical shock tube

下载: 全尺寸图片幻灯片

图 2 煤油-空气云雾临界起爆能随当量比的变化图

Figure 2. Variation of minimum ignition energy with equivalence ratio for aviation kerosene cloud

下载: 全尺寸图片幻灯片

图 3 爆速、爆压随喷雾压力的变化

Figure 3. Detonation velocity and explosion pressure of RP-3 aviation kerosene under different spray pressures

下载: 全尺寸图片幻灯片

图 4 爆速、爆压随起爆能量的变化

Figure 4. Detonation velocity and explosion pressure of RP-3 aviation kerosene under different initiation energies

下载: 全尺寸图片幻灯片

图 5 爆速、爆压随浓度当量比的变化

Figure 5. Detonation velocity and explosion pressure of RP-3 aviation kerosene under different equivalence ratios

下载: 全尺寸图片幻灯片

表 1 RP-3航空煤油组分

Table 1. Components of RP-3 aviation kerosene

(%)
Alkanes	Naphthenes			Alkyl benzenes	Indan & tetralin	Naphthalene	Naphthalene derivatives
Alkanes	Monocyclic	Bicyclic	Tricyclic	Alkyl benzenes	Indan & tetralin	Naphthalene	Naphthalene derivatives
52.2	33.8	6.0	0.1	5.1	1.3	0.6	0.9

下载: 导出CSV

表 2 RP-3航空煤油主要理化特性

Table 2. Physicochemical characteristics of RP-3 kerosene

Molecular formula	Molecular weight	Density at 20 ℃/(g·cm^-3)	Boiling point/℃	Condensation point/℃	Smoke point/℃	Theoretical air-fuel ratio	Latent heat of vaporization /(J·g^-1)	Low heating value/(kJ·m^-3)	Cetane index
C₇-C₁₆	148.33	0.79	185	-60	24.6	16	345	43 200	43

下载: 导出CSV

表 3 药量与起爆能量

Table 3. Mass and output energy of ignited materials

Initiation source	E/kJ	E₁/(MJ·m^-2)
1D	5.94	0.19
1D+1 g C4	11.78	0.37
1D+2 g C4	17.66	0.56
1D+3 g C4	23.53	0.75
1D+5 g C4	35.25	1.12
1D+8 g C4	52.82	1.68

下载: 导出CSV

表 4 不同浓度当量比下航空煤油-空气云雾的临界起爆能

Table 4. Minimum ignition energy of aviation kerosene cloud with different equivalence ratios

φ	V/mL	E₁, min/(MJ·m^-2)
0.46	19.5	0.82
0.91	39.0	0.23
1.28	54.6	0.21
1.52	65.0	0.29
1.98	84.5	0.35

下载: 导出CSV

表 5 不同起爆能量条件下的实验结果

Table 5. Experimental results under different initiation energy conditions

E₁/(MJ·m^-2)	Pressure/MPa						p_ave/MPa	Velocity/(m·s^-1)					D_ave/(m·s^-1)
E₁/(MJ·m^-2)	2^#	3^#	4^#	5^#	6^#	7^#	p_ave/MPa	3^#	4^#	5^#	6^#	7^#	D_ave/(m·s^-1)
0.37	0.35	0.29	0.27	0.23	0.25	0.26	0.26	559	520	476	488	447	498
0.56	0.81	0.40	0.38	0.35	0.34	0.35	0.36	571	537	533	521	485	529
0.75	0.82	0.47	0.45	0.43	0.43	0.42	0.44	593	560	567	631	505	571
1.12	1.30	0.76	0.56	0.66	0.64	0.66	0.66	693	614	618	606	579	622
1.68	1.70	0.94	0.77	0.73	0.86	0.96	0.85	774	712	654	649	609	680

下载: 导出CSV

表 6 不同浓度当量比下的实验结果

Table 6. Experimental results under different equivalence ratio conditions

Equivalence ratio	Pressure/MPa						p_ave/MPa	Velocity/(m·s^-1)					D_ave/(m·s^-1)
Equivalence ratio	2^#	3^#	4^#	5^#	6^#	7^#	p_ave/MPa	3^#	4^#	5^#	6^#	7^#	D_ave/(m·s^-1)
0.46	1.04	0.65	0.57	0.56	0.57	0.59	0.56	639	633	609	578	548	601
0.63	1.30	0.68	0.60	0.59	0.56	0.53	0.59	651	625	600	578	546	598
0.91	1.28	0.69	0.57	0.62	0.59	0.58	0.61	667	638	611	581	546	608
1.28	1.30	0.76	0.56	0.66	0.64	0.66	0.66	693	614	618	606	579	622
1.52	1.28	0.61	0.61	0.75	0.62	0.63	0.65	632	674	606	603	559	615
1.67	1.27	0.72	0.59	0.68	0.61	0.66	0.65	638	676	625	594	558	618
1.98	1.28	0.72	0.60	0.58	0.58	0.59	0.61	659	630	600	598	565	610

下载: 导出CSV

参考文献(15)

[1]	姚广涛, 刘宏威, 杨春浩, 等.军用车辆柴油机燃用航空煤油性能研究[J].内燃机工程, 2017, 38(1):76-80. http://edu.wanfangdata.com.cn/Periodical/Detail/jsjtxyxb201405011 YAO G T, LIU H W, YANG C H, et al.Study on the performance of jet fuel burned in diesel engine of military vehicle[J]. Chinese Internal Combustion Engine Engineering, 2017, 38(1):76-80. http://edu.wanfangdata.com.cn/Periodical/Detail/jsjtxyxb201405011
[2]	梁金虎, 王苏, 张灿, 等.RP-3航空煤油点火特性研究[J].力学学报, 2014, 46(3):352-360. doi: 10.6052/0459-1879-13-305 LIANG J H, WANG S, ZHANG C, et al.Studies on the autoignition characteristics of RP-3 aviation kerosene[J]. Chinese Journal of Theoretical and Applied Mechanics, 2014, 46(3):352-360. doi: 10.6052/0459-1879-13-305
[3]	周舟, 范玮, 靳乐, 等.单个RP-3航空煤油液滴的超临界蒸发实验研究[J].推进技术, 2016, 37(8):1422-1430. http://www.cqvip.com/QK/97609X/201608/669953817.html ZHOU Z, FAN W, JIN L, et al.Experimental investigation on super critical evaporation of RP-3 aviation kerosene droplet[J]. Journal of Propulsion Technology, 2016, 37(8):1422-1430. http://www.cqvip.com/QK/97609X/201608/669953817.html
[4]	HENG Q P, JASUJA A K, LEFEBVRE A H.Influence of air and fuel flows on gas turbine sprays at high pressures[J]. Symposium on Combustion, 1996, 26(2):2757-2762. doi: 10.1016/S0082-0784(96)80113-5
[5]	DAGAUT P, CATHONNET M.The ignition, oxidation, and combustion of kerosene:a review of experimental and kinetic modeling[J]. Progress in Energy & Combustion Science, 2006, 32(1):48-92. https://www.sciencedirect.com/science/article/pii/S0360128505000523
[6]	LIU X L, WANG Y, ZHANG Q.A study of the explosion parameters of vapor-liquid two-phase JP-10/air mixtures[J]. Fuel, 2016, 165:279-288. doi: 10.1016/j.fuel.2015.10.081
[7]	范学军, 俞刚.大庆RP-3航空煤油热物性分析[J].推进技术, 2006, 27(2):187-192. http://www.docin.com/p-1111742553.html FAN X J, YU G.Analysis of thermo-physical properties of Daqing RP-3 aviation kerosene[J]. Journal of Propulsion Technology, 2006, 27(2):187-192. http://www.docin.com/p-1111742553.html
[8]	刘宇, 曾文, 马洪安, 等.氢气添加对RP-3航空煤油着火特性的影响[J].推进技术, 2016, 37(9):1742-1751. http://www.cnki.com.cn/Article/CJFDTOTAL-TJJS201609019.htm LIU Y, ZENG W, MA H A, et al.Effects of hydrogen addition on ignition characteristics of RP-3 kerosene[J]. Journal of Propulsion Technology, 2016, 37(9):1742-1751. http://www.cnki.com.cn/Article/CJFDTOTAL-TJJS201609019.htm
[9]	朱玉红, 余彩香, 李子木, 等.航空燃料超临界热裂解过程中焦炭的形[J].石油化工, 2006, 35(12):1151-1155. doi: 10.3321/j.issn:1000-8144.2006.12.007 ZHU Y H, YU C X, LI Z M, et al.Formation of coke in thermal cracking of jet fuel under super critical conditions[J]. Petrochemical Technology, 2006, 35(12):1151-1155. doi: 10.3321/j.issn:1000-8144.2006.12.007
[10]	WANG H, SUN X, RAO G, et al.The critical energy of direct initiation in liquid fuel-air and liquid fuel-RDX powder-air mixtures in a vertical detonation tube[J]. Propellants, Explosives, Pyrotechnics, 2014, 39(4):597-603. doi: 10.1002/prep.201300177
[11]	黄勇, 解立峰, 鲁长波, 等.柴油云雾最小点火能量的实验研究[J].高压物理学报, 2015, 29(2):149-154. doi: 10.11858/gywlxb.2015.02.010 HUANG Y, XIE L F, LU C B, et al.Experimental study on minimum ignition energy of diesel-air cloud[J]. Chinese Journal of High Pressure Physics, 2015, 29(2):149-154. doi: 10.11858/gywlxb.2015.02.010
[12]	PENG L, GAO X, MANNAN M S.Prediction of minimum ignition energy of aerosols using flame kernel modeling combined with flame front propagation theory[J]. Journal of Loss Prevention in the Process Industries, 2012, 25(1):103-113. doi: 10.1016/j.jlp.2011.07.006
[13]	姚干兵. 液态碳氢燃料云雾爆轰及其抑制与泄放研究[D]. 南京: 南京理工大学, 2006: 16-18. YAO G B. Investigation on detonation characteristics of liquid fuel-air mixtures, explosion suppression and venting[D]. Nanjing: Nanjing University of Science & Technology, 2006: 16-18.
[14]	李俊, 鲁长波, 安高军, 等.汽油、甲醇汽油和乙醇汽油燃爆特性的对比研究[J].中国安全科学学报, 2016, 26(8):64-68. http://d.old.wanfangdata.com.cn/Periodical/zgaqkxxb201608012 LI J, LU C B, GAO A J, et al.Comparative study on combustion and explosion characteristics of gasoline, methanol-gasoline and ethanol-gasoline[J]. Chinese Science Safety Journal, 2016, 26(8):64-68. http://d.old.wanfangdata.com.cn/Periodical/zgaqkxxb201608012
[15]	张宝坪, 张庆明, 黄风雷.爆轰物理学[M].北京:兵器工业出版社, 2009:4-5. ZHANG B P, ZHANG Q M, HUANG F L.Detonation physics[M]. Beijing:The Publishing House of Ordnance Industry, 2009:4-5.